Patton-electronic 3196RC User Manual

Model 3196RCiDSL TDM-Digital Access Concentrator (T-DAC)User ManualSales Office: +1 (301) 975-1000Technical Support: +1 (301) 975-1007E-mail: support

10Compliance InformationRadio and TV InterferenceThe Model 3196RC generates and uses radio frequency energy, and if not installed and used properly—th

11Model 3196RC T-DAC User Manual Industry Canada NoticeNoteThis equipment meets the applicable Industry Canada Terminal Equip-ment Technical Specifica

12Model 3196RC T-DAC User Manual pany for leased line facilities. The Universal Service Order Code (USOC) is RJ48. The Facility Interface Codes (FIC)

13About this guideThis guide describes installing and configuring a Patton Electronics Model 3196RC TDM-Digital Access Concentrator (T-DAC). By the ti

14Model 3196RC T-DAC User Manual PrecautionsNotes and cautions, which have the following meanings, are used throughout this guide to help you become a

15Model 3196RC T-DAC User Manual Mouse conventionsThe following conventions are used when describing mouse actions:Garamond bold type Indicates the na

16Chapter 1 IntroductionChapter contentsModel 3196RC iDSL T-DAC overview ...

Model 3196RC iDSL T-DAC overview 17Model 3196RC T-DAC User Manual 1 • IntroductionModel 3196RC iDSL T-DAC overviewThe Model 3196RC (see figure 2) pro

Hardware overview 18Model 3196RC T-DAC User Manual 1 • IntroductionHardware overviewThe Model 3196RC combines transmission and networking technology

Hardware overview 19Model 3196RC T-DAC User Manual 1 • IntroductionLANThe 10/100-Mbps Ethernet LAN port is presented on an RJ-45 connector with an au

Patton Electronics Company, Inc.7622 Rickenbacker DriveGaithersburg, MD 20879 USATel: +1 (301) 975-1000Fax: +1 (301) 869-9293Support: +1 (301) 975-100

Hardware overview 20Model 3196RC T-DAC User Manual 1 • IntroductionSystem timingThe iDSL T-DAC's system timing may be derived from an internal c

Hardware overview 21Model 3196RC T-DAC User Manual 1 • IntroductionFigure 4. Model 3196RC front panel LEDsLED displayFront panel LEDs (figure 3) disp

Hardware overview 22Model 3196RC T-DAC User Manual 1 • IntroductionCLK SOURCE GreenOn solid The 3196RC is set as the Master Clock source.Flashing The

Approvals 23Model 3196RC T-DAC User Manual 1 • IntroductionApprovalsThe Model 3196RC T-DAC has achieved the following approvals and certifications:•

24Chapter 2 Hardware installationChapter contentsIntroduction...

Introduction 25Model 3196RC T-DAC User Manual 2 • Hardware installationIntroductionThis chapter contains the following procedures for installing the

T-DAC blades installation 26Model 3196RC T-DAC User Manual 2 • Hardware installationNoteThe T-DAC should be installed as close as possible to the ter

Cable installation 27Model 3196RC T-DAC User Manual 2 • Hardware installationCable installationThis section describes installing the network interfac

Cable installation 28Model 3196RC T-DAC User Manual 2 • Hardware installationFigure 7. Ethernet RJ-45 pin and signal definitions for T-DACConnecting

Cable installation 29Model 3196RC T-DAC User Manual 2 • Hardware installationConnecting to the T1/E1 WAN portsAn active T1/E1 is not necessary to con

3Summary Table of Contents1 Introduction...

Cable installation 30Model 3196RC T-DAC User Manual 2 • Hardware installation2. The other end of the cable has 68 non-terminated twisted-pairs for co

Cable installation 31Model 3196RC T-DAC User Manual 2 • Hardware installationConnecting the iDSL portsThe remote (CPE) iDSL modems are connected to t

Cable installation 32Model 3196RC T-DAC User Manual 2 • Hardware installationNoteThe 2-wire iDSL modem lines are polarity insensitive so you only nee

Cable installation 33Model 3196RC T-DAC User Manual 2 • Hardware installationNoteTo synchronize the ForeFront system with a BITS clock, you must conn

Completing the hardware installation 34Model 3196RC T-DAC User Manual 2 • Hardware installationCompleting the hardware installationThis section verif

35Chapter 3 Configuring the T-DAC for operationChapter contentsIntroduction...

Introduction 36Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operationIntroductionThis chapter contains the following procedures that

Initial configuration through the RS-232 control port 37Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operation• If you are using a T1

Initial configuration through the RS-232 control port 38Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operationSetting up the HyperTer

Initial configuration through the RS-232 control port 39Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operation6. Configure your COM p

4Table of ContentsSummary Table of Contents ...

Initial configuration through the RS-232 control port 40Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operation9. Connect the male end

Using a browser to complete Model 3196RC configuration 41Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operation19. Press the left-arr

Using a browser to complete Model 3196RC configuration 42Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operation5. The 3196RC Configur

Using a browser to complete Model 3196RC configuration 43Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operationFigure 22. HOME page w

Using a browser to complete Model 3196RC configuration 44Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operationfiguration changes wil

Using a browser to complete Model 3196RC configuration 45Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operation4. To enter the defaul

Using a browser to complete Model 3196RC configuration 46Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operationUnless it fails or bec

Using a browser to complete Model 3196RC configuration 47Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operation2. Click the System Cl

Using a browser to complete Model 3196RC configuration 48Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operationThe DS0 Mapping window

Using a browser to complete Model 3196RC configuration 49Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operationThe following notation

5Model 3196RC T-DAC User Manual Connecting the Ethernet ports ...

Using a browser to complete Model 3196RC configuration 50Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operation8. On the 3196RC Confi

Using a browser to complete Model 3196RC configuration 51Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operation9. On the Configuratio

Using a browser to complete Model 3196RC configuration 52Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operationConnect an E1 line, (W

Using a browser to complete Model 3196RC configuration 53Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operation15. Click the Submit b

Using a browser to complete Model 3196RC configuration 54Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operationActivating the iDSL po

Using a browser to complete Model 3196RC configuration 55Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operation• Front panel switches

Using a browser to complete Model 3196RC configuration 56Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operation2. Scroll to the table

Using a browser to complete Model 3196RC configuration 57Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operation3. Click the [change c

Using a browser to complete Model 3196RC configuration 58Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operationFigure 35. T1/E1 Link

Using a browser to complete Model 3196RC configuration 59Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operation2. From the Line Codin

6Model 3196RC T-DAC User Manual Remote loop ...

Using a browser to complete Model 3196RC configuration 60Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operationConfiguring line setti

Using a browser to complete Model 3196RC configuration 61Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operation3. Click the Configura

Using a browser to complete Model 3196RC configuration 62Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operation2. From the Line Codin

Saving your configuration 63Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operationSaving your configurationAt this point you have com

Backing up your configuration parameters 64Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operationNoteThe parameters that will be expo

Backing up your configuration parameters 65Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operationBacking up the configuration store i

Completing the installation 66Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operation– To save the displayed data as a text file, use

Completing the installation 67Model 3196RC T-DAC User Manual 3 • Configuring the T-DAC for operationNoteIf the T-DAC does not behave as described, th

68Chapter 4 Operation and shutdownChapter contentsIntroduction...

Introduction 69Model 3196RC T-DAC User Manual 4 • Operation and shutdownIntroductionThis chapter describes how to start up and power down the Model 3

7List of Figures1 Ferrite location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

70Chapter 5 Troubleshooting and maintenanceChapter contentsIntroduction...

Introduction 71Model 3196RC T-DAC User Manual 5 • Troubleshooting and maintenanceIntroductionThis chapter describes troubleshooting and fault analysi

Fault analysis 72Model 3196RC T-DAC User Manual 5 • Troubleshooting and maintenanceFault analysisThe following procedures outline steps you should fo

Fault analysis 73Model 3196RC T-DAC User Manual 5 • Troubleshooting and maintenanceSYSTEM Front panelGreen Flash-ingThe Model 3196RC is operating nor

Basic iDSL and T1/E1 test modes 74Model 3196RC T-DAC User Manual 5 • Troubleshooting and maintenanceBasic iDSL and T1/E1 test modes Model 3196RC T-DA

Basic iDSL and T1/E1 test modes 75Model 3196RC T-DAC User Manual 5 • Troubleshooting and maintenanceFigure 52. Local loopbackTo select local loop go

Basic iDSL and T1/E1 test modes 76Model 3196RC T-DAC User Manual 5 • Troubleshooting and maintenanceTo activate remote loop, do the following:1. Go t

Basic iDSL and T1/E1 test modes 77Model 3196RC T-DAC User Manual 5 • Troubleshooting and maintenanceT1/E1 port test modesThe 3196RC offers a number o

Periodic maintenance 78Model 3196RC T-DAC User Manual 5 • Troubleshooting and maintenanceDSX1 line loop (dsxLineLoop)When activated, data received at

Maintenance 79Model 3196RC T-DAC User Manual 5 • Troubleshooting and maintenanceMaintenanceThis section describes replacing the Model 3196RC.Replacin

8Model 3196RC T-DAC User Manual 48 3196RC Configuration Menu home page . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Maintenance 80Model 3196RC T-DAC User Manual 5 • Troubleshooting and maintenance2. On the Configuration Menu pane, click the Import/Export hyperlink

Maintenance 81Model 3196RC T-DAC User Manual 5 • Troubleshooting and maintenance3. To make a back-up copy of the configuration file currently stored

Maintenance 82Model 3196RC T-DAC User Manual 5 • Troubleshooting and maintenance– To save the displayed data as a text file, use your browser’s Save

Maintenance 83Model 3196RC T-DAC User Manual 5 • Troubleshooting and maintenance3. Unlock the handles by pressing the red button on each handle. The

Maintenance 84Model 3196RC T-DAC User Manual 5 • Troubleshooting and maintenanceCompleting the installationThis section verifies that the Model 3196R

85Chapter 6 Contacting Patton for assistanceChapter contentsIntroduction...

Introduction 86Model 3196RC T-DAC User Manual 6 • Contacting Patton for assistanceIntroductionThis chapter contains the following information:• “Cont

Warranty Service and Returned Merchandise Authorizations (RMAs) 87Model 3196RC T-DAC User Manual 6 • Contacting Patton for assistanceReturn for credi

88Appendix A Network Ports (RJ-21X) connector pin-outChapter contentsIntroduction...

Introduction 89Model 3196RC T-DAC User Manual A • Network Ports (RJ-21X) connector pin-outIntroductionFigure 60 shows the pin-out for the RJ-21X 50-p

9List of Tables1 General conventions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Introduction 90Model 3196RC T-DAC User Manual A • Network Ports (RJ-21X) connector pin-outPort 151540Slate/BlackBlack/SlatePort 161641Blue/YellowYell

91Appendix B WAN Network Module connector pinoutChapter contentsIntroduction...

Introduction 92Model 3196RC T-DAC User Manual B • WAN Network Module IntroductionThe WAN

68-Pin Telco pinout 93Model 3196RC T-DAC User Manual B • WAN Network Module Port 5/RX 10